Remodeling & New Construction
New Construction Plumbing in Front Royal, VA
Building a house or putting on an addition is a one-shot deal. The plumbing goes in the walls and under the slab before the drywall, and once it is buried, it stays buried. We are a father and son crew with 45 years between us, and we get the rough-in right the first time.
540-671-5417Free quotes. We show up, and we tell you straight.
This is the work you only do once, so do it right
New construction plumbing is not a repair. Nothing is broken yet. The whole point is to install a clean, code-correct water and drain system the first time, then never have a reason to open the walls again. That changes how we think about every joint, every slope, and every fitting. A repair page is about chasing a failure. This is about preventing one for the next thirty years.
When we rough in a new home or addition in the Shenandoah Valley, we are planning around things that show up here and not everywhere: long winters that freeze unprotected lines on an exterior wall, homes on well water that need their own supply layout, and lots that sit on rock where the drain runs have to be planned, not improvised. If you are building near Front Royal, you want a plumber who already knows the ground, the inspectors, and the winters. That is us.
We work straight off your plans. If the layout has a problem, we tell you before we cut a single pipe, not after the inspector flags it. A plumbing rough-in is the cheapest thing on a job site to fix on paper and the most expensive thing to fix once the concrete is poured and the studs are closed up. We would rather have the hard conversation early.
Fixture and drain repair in Front RoyalWhen you need a new construction plumber
If any of these describe your project, you are at the stage where the plumbing decisions get made. Call before the slab goes down or the framing closes in.
You are building a new houseThe whole supply, drain, waste, and vent system starts from nothing. Fixture locations, water heater placement, and the main run all get set now.
See residential
You are adding a room with water in itA new bathroom, a kitchen addition, a laundry room, or an in-law suite all need new supply and drain lines tied into the existing house.
See services
Your builder needs a plumber on the scheduleGeneral contractors need a rough-in crew that hits inspection dates and does not hold up the drywall. We coordinate with the build, not against it.
See services
You are finishing a basementRoughing in a basement bath or wet bar means cutting the slab and tying into the main drain below grade. Plan it before the floor is finished.
See residentialYou are setting fixtures after the buildEven if the rough-in is done, the trim-out, setting the toilets, sinks, tubs, and the water heater, has to be done right or you will be calling about leaks the first week.
See remodelingHow Ajax plumbs a new build, start to finish
A new construction job is not one visit. It is a sequence tied to where the rest of the build is, and we show up at each stage to do our part so the trades behind us are not waiting on us. Here is the order it actually happens in.
Below the slab
Before any concrete is poured, the drain, waste, and vent lines that run under the floor go in. We set the slope on every drain line so waste actually moves, tie into the building sewer or septic line, and pressure test it. Once it passes the underground inspection, the slab can go down over it. Get this wrong and you are jackhammering a finished floor later.
Inside the open walls
With the framing up and the roof on but the walls still open, we run all the water supply lines, the drain and vent stacks, and stub out every fixture location. We protect lines on exterior walls from freezing, keep supply lines away from the cold side of the insulation, and set the water heater connections. Then it gets pressure tested and inspected before insulation and drywall go up.
After the finishes
Once the walls are closed, painted, and the cabinets and flooring are in, we come back to set the fixtures. Toilets, sinks, faucets, tubs, showers, the disposal, and the water heater all get installed and connected. We run water to everything, check for leaks at every joint, and make sure every fixture drains and fills the way it should before you move in.
What you can expect working with us
We are a small outfit on purpose. When you hire Ajax for a new build, you get the two of us, not a rotating crew of subs you never meet. The same hands that plan the rough-in are the hands that set your fixtures. That means nothing falls through the cracks between phases, and there is one number to call if you have a question.
We coordinate with your builder’s schedule so we are there when the job is ready for us and gone when it is not. We hit the inspection dates. We pull what needs pulling and we do not cut corners that a future inspection, or a future winter, will expose. If we see a fixture location on the plans that is going to give you grief later, a tub drain with no room for a proper trap, a water heater jammed somewhere it will be miserable to service, we tell you while it can still be moved cheaply.
Most of all, you can reach us. We pick up the phone, we show up when we say we will, and we tell you straight what the job needs. That is the whole reputation, and on a build that takes months, having a plumber who actually answers matters more than people think.
Honest pricing on a new build
New construction plumbing is priced off the plans, the fixture count, and how the lines have to run. We give you a real number up front, and the quote is free.
The cost of plumbing a new home or addition comes down to how many fixtures you are setting, how far the lines have to travel, whether you are on a slab or a crawlspace, and whether you are on public water and sewer or a well and septic. A two-bath house is a different job than a four-bath house with a basement wet bar, and we price it to match.
We do not pad the bid with fixtures you did not ask for, and we do not lowball it to win the job and then nickel-and-dime you with change orders. The number we give you is the number we expect to do the work for. If something on the plans changes, the framing moves, you add a bathroom, we tell you what that does to the price before we do it. Free quotes, no surprises, and a straight answer about what your build actually needs.
Built for Front Royal and Valley homes
Plumbing a new build in this part of Virginia is not the same as plumbing one in a warm flat suburb. We rough in for the winters we actually get. Lines on exterior walls get kept on the warm side of the insulation, hose bibs get the frost-free treatment, and any run that has a shot at freezing gets planned around, not hoped over. A frozen line in January is a burst line, and the place to prevent it is during the rough-in, not after.
If your lot is on well water, the supply side of the build looks different than a public-water hookup, and we plan the layout to match the pressure tank, the pump, and any treatment you are running. We have done this on plenty of homes around Front Royal and the Shenandoah Valley where the water comes out of the ground, not a meter.
We also build for the homes that come after the new one. A lot of our repair work is on older Valley houses, so we know exactly which shortcuts cause callbacks twenty years down the road. We do not put those shortcuts into the houses we plumb new. The goal is a system you forget about, because it just works.
We serve Front Royal, the wider Shenandoah Valley, Northern Virginia, and the Eastern Panhandle of West Virginia. If you are building in our area and need a plumber who knows the ground and the inspectors, see our recent work on the project gallery or reach out and we will walk your plans with you.
Need a plumber in Front Royal, VA?
Tell us what is going on and a real person calls you back, usually within the hour. The quote is always free.
Rather talk now? Call 540-671-5417, 24/7.
New construction plumbing questions
When in the build should I bring a plumber in?
As early as you can, ideally while the plans are still being finalized. The underground plumbing has to go in before the slab is poured, so if you wait until the framing is done you may have already locked in a layout that costs more to plumb. Getting us on the plans early lets us flag fixture locations and line runs that would cause headaches later, while they are still cheap to change.
Do you work directly with my general contractor?
Yes. Most of our new construction work is coordinated with a builder’s schedule. We come in for the underground, the rough-in, and the trim-out at the right points in the build so we are not holding up the other trades and they are not holding up us. We hit the inspection dates and keep the job moving.
What is the difference between rough-in and trim-out?
Rough-in is all the work that gets buried, the supply lines, drains, vents, and fixture stubs that go in while the walls are still open. Trim-out is the finish work after the walls are closed and painted, setting the actual toilets, sinks, faucets, tubs, and the water heater. A full new build needs both, done at different stages months apart.
Can you plumb a home on well water and septic?
Yes, and we do it regularly around Front Royal and the Valley. A well-and-septic build has a different supply layout than a public-water-and-sewer one. We plan around your pressure tank, pump, and any water treatment on the supply side, and tie the drain system into the septic line instead of a public sewer. We set the slope and venting the same careful way either way.
How do you keep new plumbing from freezing in winter?
It is built in during the rough-in. We keep water lines on the warm side of the insulation and away from the cold exterior face of the wall, use frost-free hose bibs on the outside, and plan any run that could freeze so it does not. The time to prevent a frozen line is before the walls are closed, which is exactly why the rough-in stage matters so much in this climate.
Are quotes for new construction free?
Yes. We give a free quote on new construction plumbing priced off your plans, your fixture count, and how the lines have to run. The number we quote is the number we expect to do the work for, and if the plans change we tell you what that does to the price before we do the extra work.
Do you handle additions, not just whole new homes?
Absolutely. Additions with water in them, a new bathroom, a kitchen expansion, a laundry room, a finished basement bath, all need new supply and drain lines tied into your existing house. That tie-in is its own skill, and we handle it the same careful way we handle a full new build. Call us with what you are adding and we will take a look.